ELECTRICAL PROBLEMS
#1
08-26-2008, 01:57 PM
Join Date: Oct 2007
Posts: 13
Likes: 0
Received 0 Likes
on
0 Posts
ELECTRICAL PROBLEMS
02 SCRAMBLER --DOES NOT CHARGE. REGULATOR MELTED. WHAT CAUSED IT TO MELT? IF I INSTALL ANEW ONE WILL IT GET WRECKED TOO. CAN I TEST STATOR?
04 400 SPORTSMAN-- CUTS OUT 4600-5000 RPM DOES NOT STALL. WORKES FINE AT LOW SPEEDS, SOME TIMES IF YOU LET OFF AND THEN PUNCH THROTTLE
IT WILL BE FINE. CLEANED CARB--OK, REV LIMITER ?, CDI
04 400 SPORTSMAN-- CUTS OUT 4600-5000 RPM DOES NOT STALL. WORKES FINE AT LOW SPEEDS, SOME TIMES IF YOU LET OFF AND THEN PUNCH THROTTLE
IT WILL BE FINE. CLEANED CARB--OK, REV LIMITER ?, CDI
#2
08-26-2008, 03:57 PM
ELECTRICAL PROBLEMS
Were you running the scrammy with a fried battery? If so, the regulator will be pumping voltage into the battery as hard as it can and eventually it will ruin the regulator. I just had to replace the the rectifier/regulator on my Arctic Cat because I was too lazy to put a new battery in. (Hey, it always cranked on the first pull!) I'm sure there is a test for stator output but i'm not that familiar with the Polaris' electrical system. Luckily I haven't had to do anything to my old trail boss. It just keeps on going, and going, and going........................
Thread
Thread Starter
Forum
Replies
Last Post
ranvette
Polaris Ask an Expert! In fond memory of Old Polaris Tech.
2
07-04-2015 06:13 PM
Currently Active Users Viewing This Thread: 1 (0 members and 1 guests)