stock carb problems in ds
#1
hey everyone, my ds spits back through the carb when you touch the throttle lightly. it has done it since new. its about a year old. you sit idling and push the throttle a little bit and hold it and it will spit back .sometimes it will kill the motor when you start to take off. any help appreciated
#4
#5
I just went thru that issue with mine. I even took mine to an authorized dealer who jetted the bike and adjusted the carb but did not fix the problem.
The problem is a loose wire on the ignition coil.
The ignition coil is mounted uder the tank and the wire can been seen from the left side slightly above the rev limiter. It is a black wire and the bike will start once off but tends to act up when lightly pressing the throttle.
I discovered this while installing an RPM gauge on the bike. The coils needs to be tapped in on the installation at which time I discovered the loose wire.
If you cant find the wire contact RON WOODS and ask them to fax you a copy of the installation sheet for the RPM Gauge and you will find it.
Good Luck,
Joseph Oceguera
E-mail Joemiami07@aol.com
00 DS 650
Custom X Muffler
Rotax Box
K& N Filter
Carb. Jetting
Alba Racing Kit
Nurf Bars
RPM Undercarrige Protection
6 Pack Rack
Ron woods RPM Gauge
The problem is a loose wire on the ignition coil.
The ignition coil is mounted uder the tank and the wire can been seen from the left side slightly above the rev limiter. It is a black wire and the bike will start once off but tends to act up when lightly pressing the throttle.
I discovered this while installing an RPM gauge on the bike. The coils needs to be tapped in on the installation at which time I discovered the loose wire.
If you cant find the wire contact RON WOODS and ask them to fax you a copy of the installation sheet for the RPM Gauge and you will find it.
Good Luck,
Joseph Oceguera
E-mail Joemiami07@aol.com
00 DS 650
Custom X Muffler
Rotax Box
K& N Filter
Carb. Jetting
Alba Racing Kit
Nurf Bars
RPM Undercarrige Protection
6 Pack Rack
Ron woods RPM Gauge
Thread
Thread Starter
Forum
Replies
Last Post
Hankey Pankey
Polaris Ask an Expert! In fond memory of Old Polaris Tech.
26
10-18-2020 03:50 PM
Currently Active Users Viewing This Thread: 1 (0 members and 1 guests)