2004 polaris sportsman 500 awd
#1
#2
Welcome to the forum! Both front wheels not engaging or maybe just one? Pull the front cover and check that both the small connectors for the the awd are connected and with the key on,in gear and awd on check that you have 12 volts with a test light on each gray wire in the connector harness. Place the transmission in reverse and over ride button pushed in,then check for voltage again. If you have voltage then could be problems in the hubs,but not usually both at the same time! If speedo shows you are in reverse (then transmissions switches are ok). Shows also on the wiring diagram that I have on the 04 model the over ride went through the speedometer as an indicator and to complete the circuit. If you don't have power on the gray awd wires in reverse the problem could be in the speedo. Others may have had this problem and may help. Didn't have this problem at the shop far as I could remember. OPT
#3
I checked the voltage and it had power in reverse with the override pushed in but still no wheel spin. ive read that you can splice some wire in the speedo to ground it off better since it is grounded through the speedo. i would hate to have to spend alot of money to send it to a shop or buy a new speedo.
#4
#6
Thread
Thread Starter
Forum
Replies
Last Post
Currently Active Users Viewing This Thread: 1 (0 members and 1 guests)